Product ID:E-58 D EMULSIFIER (SEE SUPP DATA)
MSDS Date:01/01/1995
FSC:6850
NIIN:01-264-0837
Kit Part:Y
MSDS Number: BGTNB

MET-L-CHEK COMPANY

1639 EUCLID ST
SANTA MONICA, CA 90404
US

Emergency Phone: 310-450-1111/800-424-9300(CHEMTREC)

Info Phone: 310-450-1111

Cage: 98733

MET-L-CHEK COMPANY

00000 SANTA MONICA, CA 90404 US

Telephone: 310-450-1111/FAX 310452-4046

Cage: 98733

ETHYLENE GLYCOL (SARA III)

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: 50.0%

OSHA PEL C 50 PPM

ACGIH TLV: C 50 PPM,VAPOR; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE & CHRONIC- EYES:MAY CAUSE MILD IRRITATION/REDNESS.
SKIN:MODERATE IRRITATION WITH PROLONGED/REPEATED CONTACT.
INHALE:INHALATION OF VAPORS GENERAT ED AT HIGH TEMPERATURES MAY
CAUSE IRRITATION & CAN CAUSE CNS DEPRESSION. ORAL:MODERATELY TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, NAUSEA, VOMITING,
DIZZINESS, HEADACHE
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:I F CONSCIOUS, DRINK WATER & INDUCE VOMITING. CALL A
PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY. NEVER GIVE FLUID OR
INDUCE VOMITING IF PATIENT IS UNCONSCIOUS OR HAS CONVULSIONS.

Flash Point Method:PMCC
Flash Point:232F,111C
Autoignition Temp:Autoignition Temp Text:775F
Lower Limits:3.2
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, ALCOHOL FOAM, WATER
FOG. USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINER.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST/RUPTURE IN INTENSE
OF HEAT. WILL IGNITE IN AIR AT ABOUT 775F.

Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNT OF WATER IF
PERMITTED. OTHERWISE, ABSORB SPILL WITH INERT MATERIAL SUCH AS
VERMICULITE. PLACE IN A CONTAINER FOR DISPOSAL. CLEAN AREA
THOROUGHLY TO REMOVE RESIDUAL CON TAMINATION. PREVENT RUNOFF FROM
ENTERING SEWERS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL AND VENTILATED LOCATION.
DO NOT STORE NEAR OXIDIZING MATERIAL. AVOID PHYSICAL DAMAGE TO
CONTAINERS.
Other Precautions:AVOID BREATHING VAPORS. DO NOT GET IN EYES, ON SKIN
OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. REMOVE CONTAMINATED CLOTHING PROMPTLY. LAUNDER BEFORE
REUSE. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS TO AN ACCEPTABLE LEVEL, A NIOSH-APPROVED ORGANIC
VAPOR RESPIRATOR MUST BE WORN.
Ventilation:LOCAL EXHAUST OR MECHANICAL(GENERAL) AS REQUIRED TO
MAINTAIN TLV OR BELOW TLV.
Protective Gloves:RUBBER, LATEX
Eye Protection:SAFETY GLASSES/GOGGLES
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
NSN FOR A 2 PART KIT OF TYPE I,METHOD D,LVL 3 OR MIL-I-25135D;PER
QPL-25135-15, THE SET MAY CONSIST OF FP-95A(M) PENETRANT AND E-58A
OR E-58D EMULSIFIER.THE MFR MAY SUPPLY EITHER E-58A OR E-58D EMULSI
FIER WITH FP-95A(M) PENETRANT UNDER THIS NSN;KEY1:N1;THIS DATA
ENTRY DESCRIBES:E-58A EMULSIFIER;SEE PNI-A FOR PENETRANT.

HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:380F,193C
Vapor Pres:0.12
Spec Gravity:1.2 APPROX.
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT REDDISH PINK LIQUID - PRACTICALLY ODORLESS

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. CAN BE BURNED OR FLUSHED TO SEWER WITH
LARGE AMOUNT OF WATER IF PERMITTED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.